KNOWN FAULTS · Audi

Known faults for the Audi A6 (C5).

2000–2004 · Petrol / Diesel

Sources are not verified in real time and no entry confirms that your car is affected.

2 known faults with sources

Engines: 1.8 T / 2.4 / 2.8 (Petrol) · 1.9 TDI (Diesel) · 2.5 TDI V6 (Diesel) · S6 (4.2 V8) (Petrol) · RS6 (4.2 V8 biturbo) (Petrol)

Applies if: Only if fitted with the automatic gearbox described in the record.

Audi Multitronic (CVT) gearboxAutomatic gearbox

Engine / equipment: Multitronic continuously variable gearbox (01J and successors) in front-wheel-drive Audis: A4 B6/B7/B8, A5 8T and A6 C5/C6/C7
Period mentioned: 2000–2014
Symptoms: Judder or vibration when pulling away (especially uphill), a slipping feeling at low revs, jerky acceleration and limp mode with limited speed; sometimes a burning smell.
Possible cause described: Known failures of the variator chain and pulleys, the hydraulic and electronic control unit and the clutch pack. Audi issued service bulletins, and forums report failures even with the recommended fluid changes, although poor maintenance speeds them up.
Check for the garage: Read the gearbox codes with Audi-compatible equipment, check the fluid change history and, at a specialist, judge whether fluid and a clutch adaptation are enough or the control unit or variator needs repair. With limp mode or a burning smell, stop driving.
Cost cited in the source: A UK specialist says a judder checked early usually costs a few hundred pounds, while ignoring it can end in a full rebuild.A rough figure from the original database, not an up-to-date quote.

Engines: 1.9 TDI (Diesel)

PD TDI camshaft, injectors and cylinder headInjection / cylinder head

Engine / equipment: 1.2, 1.4, 1.9 and 2.0 TDI unit-injector (PD) engines, including the VW-sourced 2.0 CRD in Chrysler, Dodge and Jeep
Period mentioned: 2000–2010
Symptoms: Growing noise from the cylinder head, power loss and rough running (cams and lifters); unstable idle, smoke or hesitation (injectors); on the 16-valve 2.0 TDI, coolant loss with no visible leak from a cracked head.
Possible cause described: The camshaft also drives the unit injectors and carries a heavy load: without VW 505.01 oil the lobes and lifters wear. 2.0 TDI PD injectors fail frequently. Some 16-valve 2.0 TDI heads (part number ending in A) crack; VW considered it fixed by the end of 2006.
Check for the garage: Check the oil history (VW 505.01), listen to the head, check injector balance rates with a diagnostic tool and, on the 16-valve 2.0 TDI, read the head part number (03G 103 351) and look for coolant loss.
Cost cited in the source: Camshaft and lifters: approx. €400–800; 2.0 TDI PD injectors: €900–2,000A rough figure from the original database, not an up-to-date quote.

Mileage cited in the database: 120,000–200,000 km. This is not a maintenance interval and does not predict a failure.