Known faults for the Citroën Berlingo (II).

Engine / equipment

1.0 / 1.2 PureTech (EB2) in the Peugeot 208/2008/308/3008/5008, Citroën C3/C4/C5 Aircross, DS 3, Opel Corsa/Crossland/Grandland

Period mentioned

2012 – approx. 2022

Symptoms

Oil pressure warning, hard brake pedal or reduced assistance, oil consumption, blue smoke, squeal at the front of the engine, turbo whistles or loses power.

Possible cause described

The timing belt runs in oil and degrades (especially with short trips and fuel dilution). Debris clogs the oil pump strainer, the brake vacuum pump filter, the turbo oil feed and the variable valve timing solenoids. Stellantis announced compensation for affected owners in 2025.

Check for the garage

Measure the belt through the oil filler opening with the manufacturer's tool. Confirm whether the vacuum pump campaign was done.

Cost cited in the source

Vacuum pump: €500–800; belt with oil system cleaning: considerably moreA rough figure from the original database, not an up-to-date quote.

Sources from the original database

Engine / equipment

Naturally aspirated 1.4 and 1.6 VTi from the Prince family (EP3/EP6C), including the MINI One and Cooper 1.4/1.6 (N12/N16)

Period mentioned

2006–2017

Symptoms

Chain rattle on cold starts, unstable idle, stalling and an engine light with variable valve timing codes (P1030, P1062, P101A, P1025).

Possible cause described

The chain stretches and the tensioner fails early, often before 100,000 km. A stretched chain throws the timing out and makes the Valvetronic learning fail, which gets mistaken for a Valvetronic fault.

Check for the garage

Listen to a cold start and check the timing and chain condition before replacing Valvetronic parts or repeating adaptations.

Cost cited in the source

Tensioner and chain: approx. €750–1,700 (converted from dollars)A rough figure from the original database, not an up-to-date quote.

Mileage cited in the database: up to 100,000 km. This is not a maintenance interval and does not predict a failure.

Sources from the original database

Engine / equipment

1.6 HDi DV6 (Peugeot 207/308/3008/Partner, Citroën C3/C4/Berlingo; same engine as the Ford 1.6 TDCi)

Period mentioned

Approx. 2004–2015

Symptoms

Loud turbo whistle, power loss, blue or black smoke, oil that gets dirty very quickly. Before the failure, often a puffing or ticking from the cylinder head and an exhaust smell from an injector.

Possible cause described

The injector clamp bolts work loose, the gas leak forms carbon that gets into the oil and clogs the mesh filter in the banjo bolt feeding the turbo. The turbo is starved of oil. Replacing only the turbo does not fix it.

Check for the garage

Check injector bolt torque and carbon at their base, the turbo banjo bolt and the sump strainer.

Cost cited in the source

Turbo + full oil system cleaning: approx. €900–2,000 (estimate)A rough figure from the original database, not an up-to-date quote.

Sources from the original database

Engine / equipment

1.5 / 1.6 / 2.0 BlueHDi with AdBlue (Peugeot, Citroën, DS, Opel)

Period mentioned

Approx. 2014 onwards

Symptoms

Emission system fault message and a “starting impossible in X km” countdown, AdBlue/UREA warning and engine light.

Possible cause described

Failure of the AdBlue tank pump module (circuit board, pressure sensor or heater) or of the AdBlue injector. The engine does not stop while driving, but once the countdown reaches zero it will not restart.

Check for the garage

Diagnose with Diagbox or equivalent: AdBlue pressure, flow test and tank temperature.

Cost cited in the source

Complete module or tank: approx. €600–1,500 (estimate)A rough figure from the original database, not an up-to-date quote.

Sources from the original database