KNOWN FAULTS · Citroën

Citroën C5 (X7) 2.0 HDi / BlueHDi common problems.

2008–2017 · Diesel

Sources are not verified in real time and no entry confirms that your car is affected.

2 known faults with sources

Applies if: Only the BlueHDi versions (with AdBlue).

AdBlue system failure (start countdown)Exhaust and emissions (AdBlue)

Engine / equipment: 1.5 / 1.6 / 2.0 BlueHDi with AdBlue (Peugeot, Citroën, DS, Opel)
Period mentioned: Approx. 2014 onwards
Symptoms: Emission system fault message and a “starting impossible in X km” countdown, AdBlue/UREA warning and engine light.
Possible cause described: Failure of the AdBlue tank pump module (circuit board, pressure sensor or heater) or of the AdBlue injector. The engine does not stop while driving, but once the countdown reaches zero it will not restart.
Check for the garage: Diagnose with Diagbox or equivalent: AdBlue pressure, flow test and tank temperature.
Cost cited in the source: Complete module or tank: approx. €600–1,500 (estimate)A rough figure from the original database, not an up-to-date quote.

Applies if: Only the 2.0 HDi (DW10); the BlueHDi has its own AdBlue sheet.

2.0/2.2 HDi DPF, EGR, turbo and flywheelDPF / EGR / turbo / flywheel

Engine / equipment: PSA 2.0 HDi (DW10) and 2.2 HDi (DW12), including the 2.0/2.2 JTD in the Fiat Ulysse and Scudo and the Lancia Phedra
Period mentioned: 1998–2015
Symptoms: Particulate filter warning and power loss; rough idle from a dirty EGR; vibration and knocks when starting or in low gears (dual-mass flywheel); smoke or hesitation from injectors at high mileage.
Possible cause described: The engine itself is very robust, but the ancillaries are not: the DPF with Eolys additive clogs in town use, the EGR and its cooler fill with soot, the variable-geometry turbo sticks and the dual-mass flywheel wears. The 136 hp versions have more problems than the 138 to 163 hp ones.
Check for the garage: Read the DPF status and additive level, check the EGR and cooler, check the dual-mass flywheel at start-up and measure injector balance rates.
Cost cited in the source: Forced DPF regeneration: €100–150; new DPF: €800–1,500; rebuilt injector: €200–250A rough figure from the original database, not an up-to-date quote.

Mileage cited in the database: 120,000–180,000 km. This is not a maintenance interval and does not predict a failure.