KNOWN FAULTS · Hyundai

Hyundai i30 (I) 1.4 / 1.6 / 2.0 common problems.

2007–2012 · Petrol

Sources are not verified in real time and no entry confirms that your car is affected.

2 known faults with sources

Applies if: Only the 1.4 and 1.6 petrol (Gamma).

Timing chain on the 1.4 and 1.6 Gamma petrol enginesValve timing

Engine / equipment: 1.4 and 1.6 CVVT (Gamma): Hyundai i30, i20 and ix20; Kia Cee'd, Venga, Soul and Rio
Period mentioned: Approx. 2006–2013
Symptoms: Chain rattle on cold start or under load, engine warning light and, in the worst case, the chain jumping with serious engine damage.
Possible cause described: The ADAC lists the timing chain as a typical defect of the i30 I and Cee'd I (especially 2009–2010 model years); on the Rio III the 1.4 CVVT could stretch its chain early. The wrong oil or late changes make it worse.
Check for the garage: Listen on a cold start; read the camshaft–crankshaft correlation codes; replace chain, tensioner and guides if it rattles; keep to the oil-change intervals.
Cost cited in the source: No verified estimate; ask the garage for a quote.A rough figure from the original database, not an up-to-date quote.

Applies if: Weak points of this model from inspections, breakdown statistics and recalls; anything specific to one engine is stated in the sheet.

ADAC breakdowns, rust and recalls on the first-generation i30Known weak points

Engine / equipment: Hyundai i30 I (FD), petrol and diesel
Period mentioned: 2007–2012
Symptoms: Battery (2008–2012), immobiliser (2008–2010), fuel pump (2009–2011), lights, timing chain (2008–2012) and crankshaft sensor (2008–2010) in the ADAC statistics; brakes and suspension flagged at the roadworthiness test; rust on door edges, floor and tailgate; on diesels, owners report cracked cylinder heads.
Possible cause described: The TÜV report calls it a “defect giant”. Recalls: brake-light switch (2006–2011), parking brake that does not fully release (2010–2012), steering-column bolt (2007–2012), steering-angle sensor software (2009–2010), airbag control-unit programming and an ABS module short-circuiting from dirt or moisture with fire risk (2005–2011).
Check for the garage: Check outstanding recalls by VIN (manufacturer, KBA or ADAC website) and have a garage inspect the points listed before buying or before the roadworthiness test.
Cost cited in the source: No verified estimate; ask the garage for a quote.A rough figure from the original database, not an up-to-date quote.