KNOWN FAULTS · Hyundai

Hyundai Tucson (IV) 1.6 T-GDi Plug-in Hybrid common problems.

2020–2026 · Plug-in hybrid

Sources are not verified in real time and no entry confirms that your car is affected.

3 known faults with sources

Applies if: US bulletin for cars built from 2021 to 2025; in Europe, ask the dealer.

Wipers that do not return to their rest position because of a loose motor crank arm nutVisibility / electronics

Engine / equipment: Tucson (IV), all engines
Period mentioned: 2021–2025
Symptoms: When switched off, the front wipers do not go back down: they stop halfway up the glass or in a different place each time. They sweep normally while working.
Possible cause described: The nut joining the crank arm (the linkage arm) to the wiper motor shaft works loose and the rest position goes out of adjustment. In the US, Hyundai extended the warranty on that nut to 10 years or 100,000 miles (extension Z08, bulletin 26-BD-007H) for Tucsons built from 2021 to 2025.
Check for the garage: Tell the garage that they stop in different places when switched off and ask them to check the tightness of the motor crank arm nut before replacing the wiper motor. The warranty extension is for the US; in Europe, ask the dealer.
Cost cited in the source: No verified estimate; ask the garage for a quote.A rough figure from the original database, not an up-to-date quote.

Carbon on the injectors and intake of the T-GDi petrol enginesInjection / turbo

Engine / equipment: Hyundai and Kia 1.0 and 1.6 T-GDi direct-injection turbo petrol engines
Period mentioned: 2015 onwards
Symptoms: Loss of power, higher consumption, hesitation or rough idle, usually at high mileage.
Possible cause described: With direct injection, petrol does not wash the intake valves and carbon builds up on the injectors and intake. German guides mention it for the i20 III, Tucson IV and Picanto III (dirty injectors).
Check for the garage: Read misfire and fuel-trim codes; inspect the injectors and valves with a borescope; clean the intake if there are deposits.
Cost cited in the source: No verified estimate; ask the garage for a quote.A rough figure from the original database, not an up-to-date quote.

Applies if: Weak points of this model from inspections, breakdown statistics and recalls; anything specific to one engine is stated in the sheet.

Airbags, hybrid software and water leaks on the Tucson IVKnown weak points

Engine / equipment: Hyundai Tucson IV (NX4)
Period mentioned: 2020 onwards
Symptoms: Rattles from badly fitted trim or wheel-arch liners, water leaks after heavy rain and, on the 48 V system, stop-start that only works with a well-charged battery.
Possible cause described: Recalls in Germany: almost 200 early cars with incorrectly fitted airbags and, in summer 2021, a software update of the hybrid control unit (HCU) for the immobiliser on about 4,000 Tucson hybrids. The guide says it is not yet clear whether the other faults are isolated cases.
Check for the garage: Check outstanding recalls by VIN (manufacturer, KBA or ADAC website) and have a garage inspect the points listed before buying or before the roadworthiness test.
Cost cited in the source: No verified estimate; ask the garage for a quote.A rough figure from the original database, not an up-to-date quote.