KNOWN FAULTS · Kia

Kia Cee'd (II) 1.4 / 1.6 CRDi common problems.

2012–2018 · Diesel

Sources are not verified in real time and no entry confirms that your car is affected.

2 known faults with sources

Applies if: Diesel CRDi of the U family; the specific points were documented on other models with the same type of engine.

Weak points of the small CRDi diesels (U family) from Hyundai and KiaInjection / turbo

Engine / equipment: 1.1, 1.4, 1.5, 1.6 and 1.7 CRDi diesels (U family): Rio, Venga, Soul, Stonic, Cee'd, Carens, Optima, i20, ix20, i30, i40, ix35, Tucson, Accent, Matrix
Period mentioned: Approx. 2005 onwards
Symptoms: At high mileage or with short trips: carbon in injectors and EGR, a clogged particulate filter, dual-mass flywheel and turbo; isolated cases of a stretched chain (1.7) and cracked heads (early 1.6); a clutch that wears early; on some cars, a cracked silencer (1.1) or the brake-servo vacuum pump (1.7 campaign).
Possible cause described: German guides rate these engines as robust if maintained: the faults are the typical wear of a modern diesel. Specific points: a stretched chain on some 1.7s (ix35), cracked heads cited by the TÜV on the i30 I, the 1.1 silencer (Rio III), diesel clutches at 60,000–100,000 km (Cee'd I) and a recall of the 1.7 CRDi vacuum pump (5/10/2010–30/4/2011).
Check for the garage: Drive long trips to regenerate the filter; listen to the chain when cold; test injectors and EGR; check the vacuum-pump campaign by VIN on the 1.7.
Cost cited in the source: No verified estimate; ask the garage for a quote.A rough figure from the original database, not an up-to-date quote.

Applies if: Only with the 7-speed dual-clutch automatic (7DCT). Confirm the gearbox type.

Judder on the 7-speed dual-clutch gearbox (7DCT)Automatic gearbox

Engine / equipment: 7-speed dry dual-clutch automatic (7DCT)
Period mentioned: Approx. 2015–2021
Symptoms: Abnormal vibration or shudder when pulling away and at low speed, especially in traffic.
Possible cause described: Dual-clutch behaviour at low speed; Hyundai and Kia issued technical bulletins with new gearbox software (anti-judder logic) and, if that is not enough, a clutch replacement.
Check for the garage: At the dealer: run the judder test with the diagnostic tool, install the latest gearbox software and replace the dual clutch only if the judder remains.
Cost cited in the source: No verified estimate; ask the garage for a quote.A rough figure from the original database, not an up-to-date quote.