KNOWN FAULTS · Kia

Known faults for the Kia Rio (II).

2005–2011 · Petrol / Diesel

Sources are not verified in real time and no entry confirms that your car is affected.

2 known faults with sources

Engines: 1.4 / 1.6 (Petrol) · 1.5 CRDi (Diesel)

Applies if: Only cars built from 28/10/2009 to 26/9/2011; confirm by VIN.

Internal brake-fluid leak in the ABS/ESC module of the Rio (2009–2011)Electrical and electronic systems

Engine / equipment: Second-generation Kia Rio (JB) built from October 2009 to September 2011
Period mentioned: 2009–2011
Symptoms: ABS and ESP warning lights on, a burning smell or heat near the engine fuse box.
Possible cause described: An internal brake-fluid leak in the hydraulic unit can short-circuit the ABS/ESC electrical circuit; the current rises, the fuse box overheats and there is a risk of fire in the engine bay. Rapex alert 7/2025 (Kia campaigns 241143 to 241153, almost five million cars of twelve models worldwide); on the Rio it covers cars built from 28/10/2009 to 26/9/2011.
Check for the garage: Check by VIN at a Kia dealer that the campaign was done; if the ABS/ESP lights come on, do not park the car indoors until it has been checked.
Cost cited in the source: Free under the recall.A rough figure from the original database, not an up-to-date quote.

Engines: 1.5 CRDi (Diesel)

Applies if: U-family CRDi diesel; the specific points were documented on other models with the same engine.

Weak points of the small CRDi diesels (U family) from Hyundai and KiaInjection / turbo

Engine / equipment: 1.1, 1.4, 1.5, 1.6 and 1.7 CRDi diesels (U family): Rio, Venga, Soul, Stonic, Cee'd, Carens, Optima, i20, ix20, i30, i40, ix35, Tucson, Accent, Matrix
Period mentioned: Approx. 2005 onwards
Symptoms: At high mileage or with short trips: carbon in injectors and EGR, a clogged particulate filter, dual-mass flywheel and turbo; isolated cases of a stretched chain (1.7) and cracked heads (early 1.6); a clutch that wears early; on some cars, a cracked silencer (1.1) or the brake-servo vacuum pump (1.7 campaign).
Possible cause described: German guides rate these engines as robust if maintained: the faults are the typical wear of a modern diesel. Specific points: a stretched chain on some 1.7s (ix35), cracked heads cited by the TÜV on the i30 I, the 1.1 silencer (Rio III), diesel clutches at 60,000–100,000 km (Cee'd I) and a recall of the 1.7 CRDi vacuum pump (5/10/2010–30/4/2011).
Check for the garage: Drive long trips to regenerate the filter; listen to the chain when cold; test injectors and EGR; check the vacuum-pump campaign by VIN on the 1.7.
Cost cited in the source: No verified estimate; ask the garage for a quote.A rough figure from the original database, not an up-to-date quote.