Skip to content
Emergency
KNOWN FAULTS · Opel

Known faults for the Opel Corsa F.

2019–2026 · Petrol / Diesel / Electric

Sources are not verified in real time and no entry confirms that your car is affected.

Buying it used?Which engine has the fewest documented faults, which recalls to ask the seller about and what to look for on the test drive.Before you buy

7 known faults with sources

Engines: 1.2 / 1.2 Turbo (PureTech) (Petrol)

Oil-bath timing belt degradationTiming / lubrication
Engine / equipment
1.0 / 1.2 PureTech (EB2) in the Peugeot 208/2008/308/3008/5008, Citroën C3/C4/C5 Aircross, DS 3, Opel Corsa/Crossland/Grandland
Period mentioned
2012 – approx. 2022
Symptoms
Oil pressure warning, hard brake pedal or reduced assistance, oil consumption, blue smoke, squeal at the front of the engine, turbo whistles or loses power.
Possible cause described
The timing belt runs in oil and degrades (especially with short trips and fuel dilution). Debris clogs the oil pump strainer, the brake vacuum pump filter, the turbo oil feed and the variable valve timing solenoids. Stellantis announced compensation for affected owners in 2025.
Check for the garage
Measure the belt through the oil filler opening with the manufacturer's tool. Confirm whether the vacuum pump campaign was done.
Cost cited in the source
Vacuum pump: €500–800; belt with oil system cleaning: considerably moreA rough figure from the original database, not an up-to-date quote.

Sources from the original database

PMM: 1.2 PureTech maintenanceGates Tech Zone: PureTech belt-in-oilCarchecker: Citroën C4 Cactus 1.2 PureTechAu7o: Peugeot 2008 PureTech
View full entry

Engines: 1.2 / 1.2 Turbo (PureTech) (Petrol) · 1.5 Diesel (BlueHDi) (Diesel)

Applies if: Only if fitted with the automatic gearbox described in the record.

EAT6/EAT8 jerking and torque converterAutomatic gearbox
Engine / equipment
Aisin EAT6 and EAT8 automatic gearboxes (308, 3008, 5008, 508, 2008, C4 Picasso, C5 Aircross, C4, DS 7, Grandland…)
Period mentioned
2013–2026
Symptoms
Hesitation or a jolt between 1st and 2nd, torque converter shudder in traffic, harsh or delayed shifts and a gearbox fault warning, especially on 2017–2019 3008s.
Possible cause described
Torque converter wear or drift, valve deposits from degraded oil and software faults. Peugeot treats the oil as lifetime, but dirty or low oil causes harsh shifts.
Check for the garage
Check oil level and condition, update the gearbox software at the dealer and, after an oil change, record it with DiagBox and reset the adaptations.
Cost cited in the source
Oil change and update: the most common fix; torque converter or valve body: specialist garage repairA rough figure from the original database, not an up-to-date quote.

Sources from the original database

Service4Service: Peugeot EAT6 and EAT8 gearboxesService4Service: Citroën EAT6 and EAT8 gearboxesFrench Car Forum: EAT6 oil and adaptationAutodoc: common Peugeot 3008 problems
View full entry

Engines: 1.2 / 1.2 Turbo (PureTech) (Petrol)

Applies if: Only the 1.2 Hybrid 48 V built from 1/6/2023 to 13/1/2026.

Water ingress in the 1.2 Hybrid 48 V belt starter-generatorElectrical and electronic systems
Engine / equipment
1.2 Hybrid 48 V: Peugeot 208 and 2008, Citroën C3, C3 Aircross, C4 and C4 X, DS 3, Opel Corsa, Frontera and Mokka, Jeep Avenger, Alfa Romeo Junior, Fiat 600 and Grande Panda, Lancia Ypsilon
Period mentioned
2023 onwards
Symptoms
Engine or electrical-fault warning light, a hot or burning smell under the bonnet and, in extreme cases, an engine-bay fire.
Possible cause described
There is too little clearance between the petrol particulate filter duct and the 48 V hybrid system’s guard (belt starter-generator): in humid conditions water can get in, an electric arc can form and it can overheat. Stellantis recalled about 700,000 cars worldwide (36 incidents, 12 with fire) and advises against pressure-washing the engine until the repair.
Check for the garage
Check the recall by VIN; do not pressure-wash the engine; with the warning or a burning smell, stop and park outdoors.
Cost cited in the source
Free under the recall.A rough figure from the original database, not an up-to-date quote.

Sources from the original database

Italpassion: Stellantis recalls 700,000 hybrid cars including the Alfa Romeo Junior and Fiat Grande Pandakfz-betrieb: higher fire risk in over 800,000 cars (KBA list of models and build dates)
View full entry

Engines: 1.5 Diesel (BlueHDi) (Diesel)

AdBlue system failure (start countdown)Exhaust and emissions (AdBlue)
Engine / equipment
1.5 / 1.6 / 2.0 BlueHDi with AdBlue (Peugeot, Citroën, DS, Opel)
Period mentioned
Approx. 2014 onwards
Symptoms
Emission system fault message and a “starting impossible in X km” countdown, AdBlue/UREA warning and engine light.
Possible cause described
Failure of the AdBlue tank pump module (circuit board, pressure sensor or heater) or of the AdBlue injector. The engine does not stop while driving, but once the countdown reaches zero it will not restart.
Check for the garage
Diagnose with Diagbox or equivalent: AdBlue pressure, flow test and tank temperature.
Cost cited in the source
Complete module or tank: approx. €600–1,500 (estimate)A rough figure from the original database, not an up-to-date quote.

Sources from the original database

French Car Forum: AdBlue fault on a 3008 2.0 BlueHDiFrench Car Forum: AdBlue on a 308 1.6 BlueHDiElektroda: AdBlue cases in the PSA group
View full entry

Engines: 1.5 Diesel (BlueHDi) (Diesel)

1.5 BlueHDi camshaft chainTiming system
Engine / equipment
1.5 BlueHDi (DV5): Peugeot 208/2008/308/3008/5008/508/Rifter, Citroën C3/C4/C5 Aircross/Berlingo, Opel, DS, Fiat
Period mentioned
2017–2023
Symptoms
Rattle from the top of the engine, loss of power; in severe cases the chain breaks and the engine fails.
Possible cause described
The 7 mm chain linking the two camshafts wears prematurely, influenced by soot in the oil. Stellantis replaced it with an 8 mm chain in 2023 and opened an inspection campaign.
Check for the garage
Ask the dealer whether the car is in the campaign (free inspection and replacement if needed) and whether the 8 mm chain is fitted.
Cost cited in the source
€700–1,400 for the chain; €4,000–7,000 if it breaksA rough figure from the original database, not an up-to-date quote.

Sources from the original database

Peugeot UK: official information on the 1.5 BlueHDiVienna.at: recall of 140,000 vehiclesAutobiz: Gates reinforced chain kitAutoscore: 1.5 BlueHDi (DV5)
View full entry

Engines: Corsa-e (Electric)

On-board charger failure (e-CMP)Charging (on-board charger)
Engine / equipment
e-CMP platform EVs with the Mahle on-board charger: Peugeot e-208, e-2008 and e-Rifter, Citroën ë-C4 and ë-Berlingo, DS 3 E-Tense, Opel Corsa-e, Mokka-e and Combo-e
Period mentioned
2019–2024
Symptoms
AC charging (home or public) becomes erratic, drops from 11 kW to about 7 kW or fails completely with messages such as “Charging paused” or a critical error. DC fast charging keeps working.
Possible cause described
The Mahle on-board charger, which converts AC into DC for the battery, fails. It was fitted to at least ten Stellantis EV models until 2024, when the supplier was changed. There is no recall, but in the Netherlands its warranty was extended from two to four years in 2021, and in Denmark the consumer association FDM obtained a free replacement as a known defect.
Check for the garage
Test charging on a three-phase and a single-phase AC point, read the charger codes with DiagBox and check whether it has already been replaced and by which version. Claim warranty or known-defect treatment before paying.
Cost cited in the source
New charger: approx. €1,100–3,700 (converted from dollars) or about €5,300 at a Danish dealer; often covered by warranty or as a known defectA rough figure from the original database, not an up-to-date quote.

Sources from the original database

New Mobility: complaints about Stellantis on-board chargersFDM (Denmark): known Peugeot e-2008 charger faultCarchecker: Citroën ë-C4 50 kWhAu7o: Peugeot e-208 on-board charger
View full entry

Engines: Corsa-e (Electric)

Applies if: Only cars built up to 1/8/2020.

Will not start, stalls or loses power because of the Corsa-e electric water heaterElectric powertrain
Engine / equipment
Opel Corsa-e electric
Period mentioned
2020
Symptoms
It will not go into ready-to-drive mode, it stalls or it loses power, with the diagnostic warning light on.
Possible cause described
The heating system's electric water heater has an insulation fault. According to the technical notes reported by L'argus, it affects Corsa-e cars built up to 1/8/2020: the garage reads the codes, checks the heater's insulation and replaces it if needed (about 2 h 20 min of labour).
Check for the garage
Note the dashboard messages. It is a high-voltage car: do not touch anything; at the garage, have them check the water heater's insulation before replacing the electric motor or the charger.
Cost cited in the source
No verified estimate; ask the garage for a quote.A rough figure from the original database, not an up-to-date quote.

Sources from the original database

L'argus: teething problems of the electric Opel Corsa-e and their fixes
View full entry

Engines for this model

  • 1.2 / 1.2 Turbo (PureTech)Petrol
  • 1.5 Diesel (BlueHDi)Diesel
  • Corsa-eElectric
Describe this car's symptomsSee recalls for this modelMaintenance