KNOWN FAULTS · Toyota
Toyota Yaris Verso 1.4 D-4D common problems.
2000–2005 · Diesel
Sources are not verified in real time and no entry confirms that your car is affected.
2 known faults with sources
Injectors, dual-mass flywheel and oil consumption on the 1.4 D-4D (1ND-TV)Injection / turbo
- Engine / equipment
- 1.4 D-4D (1ND-TV): Yaris, Yaris Verso, iQ, Urban Cruiser, Corolla, Auris and Verso-S
- Period mentioned
- Approx. 2001–2018
- Symptoms
- Hard starting, rough idle, smoke and loss of power; noise or vibration from the flywheel when starting and releasing the clutch; oil consumption.
- Possible cause described
- Soot builds up in the injectors and EGR valve, especially with many short trips. The dual-mass flywheel wears and, in the worst case, damages the gearbox. Failures of the rail pressure regulator and oil consumption through the turbo or crankcase ventilation are also reported.
- Check for the garage
- Read the codes, run an injector back-leak test and check the EGR. Listen to the flywheel at idle with the clutch released. Measure oil consumption.
- Cost cited in the source
- Approx. €1,000–1,600 for dual-mass flywheel and clutch (German guide).A rough figure from the original database, not an up-to-date quote.
Sources from the original database
Gebrauchtwagenberater: Toyota Yaris II (XP9), typical problemsGebrauchtwagenberater: Toyota Yaris I (XP1), typical problemsMyMotorList: Toyota 1ND-TV engine
View full entryApplies if: The Yaris Verso is derived from the Yaris I and shares its engines, MMT gearbox and most mechanicals; confirm by VIN which campaigns apply.
Oil, rust, MMT gearbox and campaigns on the Yaris IKnown weak points
- Engine / equipment
- Toyota Yaris I (petrol and 1.4 D-4D)
- Period mentioned
- 1998–2006
- Symptoms
- Oil leaking from the crankshaft seal and oil consumption on the small petrol engines; rust on rear arches, sills, tailgate and exhaust; leaking tail lights; wheel bearings, alternator, brakes and bushes; heavy clutch wear with the MMT automated gearbox.
- Possible cause described
- Recalls the guide says are closed: oil in the crankshaft sensor (the engine can stop), a B-pillar damper that could ignite with the pretensioner, a stiff accelerator pedal, airbags, seat runners, a corroded brake master cylinder and the steering column.
- Check for the garage
- Check by VIN that the campaigns were done; check rust, leaks and MMT clutch wear.
- Cost cited in the source
- No verified estimate; ask the garage for a quote.A rough figure from the original database, not an up-to-date quote.
Sources from the original database
CarWiki: known problems of the Toyota YarisGebrauchtwagenberater: Toyota Yaris I (XP1), typical problems
View full entry