Skip to content
Emergency

Before you buy a used Fiat Qubo / Fiorino.

2007–2021 · Petrol / Diesel · 2 engines

Taken only from Testigo's sourced sheets. Use it to question the seller and on the test drive: it does not confirm that any particular car is affected.

Fiat Qubo / Fiorino, real photo of this generation
M 93 · CC BY-SA 3.0 · Wikimedia Commons · Photo source

The essentials.

Typical faults by engine

The period and mileage are those mentioned by each sheet's sources. They are not a maintenance interval and do not predict that any particular car will fail.

All versions

Sheets the catalogue links to all 2 of its engines.

  • Dualogic robotised gearbox actuator and pumpGearbox
    Period mentioned
    2003–2020
    Mileage mentioned
    The sheet does not mention a mileage.

    Applies if: Only with the Dualogic robotised gearbox (not a conventional automatic or a manual).

1.4

Petrol

1.3 Multijet

Diesel

Which engine has the fewest documented faults?

Documented faults and recalls by engine for the Fiat Qubo / Fiorino
EngineDocumented faults
1.4Petrol21 with conditions
1.3 MultijetDiesel21 with conditions

According to the data we have, all its engines have the same number of documented faults.

We only count the sourced sheets we have. An engine with fewer is not guaranteed to be more reliable: it may have been studied less or sold in smaller numbers.

Official recalls: ask before you pay

We have no official recalls on record for this model. Our list is not complete: ask anyway, with the chassis number.

  1. Ask the seller for the chassis number (VIN): it has 17 characters, appears in the car's documents and can usually also be seen at the base of the windscreen.
  2. Ask an official Fiat dealer, or the brand's official website if it lets you check by chassis number, whether each recall has been done or is still outstanding for that VIN.
  3. Manufacturer recalls are normally carried out free of charge by the official service network. If one is outstanding, ask for it to be done before you close the sale.

On the test drive: what to look and listen for

Taken from each sheet's symptoms and checks. You can tick off what you have already looked at: it is saved only in this browser.

0 of 3 checked

Cylinder head / timing / ignition

  • Look out for: Coolant loss, white smoke or mayonnaise-like oil (head gasket); misfires and, if the ECU is damaged, the car will not start or cuts out.

    Ask them to check: Check the coolant level and oil filler cap, check when the belt was last changed (also by age) and test the coils before they fail.

Timing / DPF / EGR

  • Look out for: Chain rattle on cold starts; oil level rising and smelling of diesel; particulate filter warning; power loss from a dirty EGR or the turbo.

    Ask them to check: Listen to a cold start, check whether the oil is above maximum or smells of diesel, read the DPF status and check the oil change history.

Gearbox

  • Look out for: The car drops into neutral when braking or driving with a beep and “Check gearbox”, will not engage gears or is slow to engage reverse, slow and hesitant shifts, oil under the actuator and sometimes no start because it cannot select neutral. The pump's whirr is no longer heard when opening the door.

    Ask them to check: Check the battery (with a low charge the pump may not run) and the hydraulic fluid reservoir level, look for leaks under the actuator and, at a garage, read codes and measure pressure and clutch wear before replacing the whole actuator. After any repair the system must be relearned.

Sources

Every fact on this page comes from these Testigo sheets and their original sources. Sources are not checked in real time.

More Fiat buying guides

View the model pageAll buying guides