KNOWN FAULTS · Audi

Known faults for the Audi A3 (8L).

2000–2003 · Petrol / Diesel

Sources are not verified in real time and no entry confirms that your car is affected.

Buying it used?Which engine has the fewest documented faults, which recalls to ask the seller about and what to look for on the test drive.Before you buy

4 known faults with sources

Engines: 1.6 / 1.8 / 1.8 T (Petrol) · S3 (1.8 T) (Petrol)

Applies if: Only the 1.8 T.

Ignition coils on the 20-valve 1.8 TEngine

Engine / equipment: 20-valve 1.8 T: Golf IV, Bora, Passat B5, Audi A3 8L and A4 B5, Seat León
Period mentioned: Approx. 2001–2003
Symptoms: Misfires, hesitation and the engine light; the engine runs on one cylinder fewer.
Possible cause described: The individual coils on 1.8 T engines from those years failed frequently. The German guide quotes about €100–200 for coils and leads.
Check for the garage: Read the per-cylinder misfire codes and replace the affected coil (preferably with a revised one).
Cost cited in the source: Approx. €100–200 for coils and leads (German guide).A rough figure from the original database, not an up-to-date quote.

Sources from the original database

Gebrauchtwagenberater: VW Golf IV, typical problems

View full entry

Engines: 1.6 / 1.8 / 1.8 T (Petrol) · 1.9 TDI (Diesel) · S3 (1.8 T) (Petrol)

Applies if: Weak points of this model from inspections, breakdown statistics and recalls; anything specific to one engine is stated in the sheet.

Rust, TDI fifth gear and fuel gauge on the A3 8LBodywork

Engine / equipment: Audi A3 8L (petrol and TDI)
Period mentioned: 1996–2003
Symptoms: Heavy rust on the roof seam, door edges, lower side trim, third brake light and engine-bay earth points; on TDIs, fifth gear stops engaging; the pump nozzle cuts off before full and the gauge never reaches maximum; coolant loss from the expansion-tank cap.
Possible cause described: The rust was largely fixed with the first facelift. The TDI fifth gear is fixed by replacing the damaged gears (as on the Golf IV). The tank sender is faulty.
Check for the garage: Check rust on roof, doors and trims; test fifth gear on the TDI; watch the coolant.
Cost cited in the source: No verified estimate; ask the garage for a quote.A rough figure from the original database, not an up-to-date quote.

Sources from the original database

CarWiki: known problems of the Audi A3

View full entry

Engines: 1.9 TDI (Diesel)

PD TDI camshaft, injectors and cylinder headInjection / cylinder head

Engine / equipment: 1.2, 1.4, 1.9 and 2.0 TDI unit-injector (PD) engines, including the VW-sourced 2.0 CRD in Chrysler, Dodge and Jeep
Period mentioned: 2000–2010
Symptoms: Growing noise from the cylinder head, power loss and rough running (cams and lifters); unstable idle, smoke or hesitation (injectors); on the 16-valve 2.0 TDI, coolant loss with no visible leak from a cracked head.
Possible cause described: The camshaft also drives the unit injectors and carries a heavy load: without VW 505.01 oil the lobes and lifters wear. 2.0 TDI PD injectors fail frequently. Some 16-valve 2.0 TDI heads (part number ending in A) crack; VW considered it fixed by the end of 2006.
Check for the garage: Check the oil history (VW 505.01), listen to the head, check injector balance rates with a diagnostic tool and, on the 16-valve 2.0 TDI, read the head part number (03G 103 351) and look for coolant loss.
Cost cited in the source: Camshaft and lifters: approx. €400–800; 2.0 TDI PD injectors: €900–2,000A rough figure from the original database, not an up-to-date quote.

Mileage cited in the database: 120,000–200,000 km. This is not a maintenance interval and does not predict a failure.

Sources from the original database

Autoscore: 1.9 TDI PD engine Autoscore: 2.0 TDI PD engine TorqueCars: 2.0 TDI problems Auto Świat: typical 2.0 TDI PD faults ID Parts: camshaft wear on TDI PD engines

View full entry

Engines: S3 (1.8 T) (Petrol)

Applies if: Audi S3 8L 1.8 T MY1999–2003; ABS ATE MK20 part numbers 8N0907379C / 8N0614217A (ATE 10.0949-0378.3 / 10.0204-0149.4) physically confirmed and fault V64 diagnosed. Do not extend to MK60 or code 01435.

Faulty ABS pump motor V64 (01276)Brakes / electronics

Engine / equipment: S3 1.8: ATE MK20 ABS 8N0907379C / 8N0614217A
Period mentioned: Only production periods and VINs documented in the application conditions.
Symptoms: ABS warning and pump motor code 01276.
Possible cause described: Unit or pump motor failure confirmed through testing.
Check for the garage: Confirm references and V64 diagnosis; check external circuit and test unit for repair.
Cost cited in the source: No verified quote; confirm part and diagnosis.A rough figure from the original database, not an up-to-date quote.

01276

Sources from the original database

ECU Testing — S3 1.8 MY1999–2003: ABS pump V64

View full entry

Engines for this model

1.6 / 1.8 / 1.8 TPetrol
1.9 TDIDiesel
S3 (1.8 T)Petrol

Describe this car's symptoms See recalls for this model Maintenance