KNOWN FAULTS · Peugeot

Peugeot 4007 / 4008 1.6 / 2.4 common problems.

2007–2017 · Petrol

Sources are not verified in real time and no entry confirms that your car is affected.

2 known faults with sources

Applies if: Only the 4008 1.6 (2012–2017); the 2.4 is a different engine.

Sticking piston rings, oil consumption and timing chain on the Mitsubishi 1.6 (4A92)Engine

Engine / equipment: Mitsubishi 117 hp 1.6 petrol (4A92): Citroën C4 Aircross and Peugeot 4008 (also the Mitsubishi ASX)
Period mentioned: 2012–2017
Symptoms: Oil has to be topped up between changes; bluish smoke; chain rattle on cold starts.
Possible cause described: Russia’s Za Rulem magazine (2021) rates the 4A92 the least successful engine of the range: the piston rings tend to stick from as early as about 80,000 km, which raises oil consumption; the timing chain can stretch beyond 100,000 km, and the engine is very sensitive to the oil level, which should be kept at least halfway up the dipstick.
Check for the garage: Measure oil consumption between changes and check the level often; listen for the chain on a cold start; ask for the oil-change history.
Cost cited in the source: No verified estimate; ask the garage for a quote.A rough figure from the original database, not an up-to-date quote.

Applies if: Only the 4007 (2007–2012), twin of the C-Crosser; the 4008 is a different car.

Clutch, ABS/ESP module and crankshaft seal on the C-Crosser and 4007Known weak points

Engine / equipment: Citroën C-Crosser and Peugeot 4007 (Mitsubishi 2.4 petrol and 2.2 HDi)
Period mentioned: 2007–2012
Symptoms: A failing Teves ABS/ESP module (expensive repair); clutch and dual-mass flywheel failing when towing because 1st and 2nd are tall; a weak battery (warned by a “gong”). On the 2.2 HDi: a crankshaft seal that leaks oil onto the clutch (which slips, also on the DCS gearbox) and the Eolys particulate-filter additive bag exposed next to the rear wishbone.
Possible cause described: They are twins of the Mitsubishi Outlander. Cases collected by Honest John; the maker often paid part of the ABS/ESP and clutch repairs.
Check for the garage: Check the clutch does not slip; read the ABS/ESP fault memory; test the battery.
Cost cited in the source: No verified estimate; ask the garage for a quote.A rough figure from the original database, not an up-to-date quote.