KNOWN FAULTS · Toyota
Toyota C-HR (I) 1.2 T common problems.
2016–2023 · Petrol
Sources are not verified in real time and no entry confirms that your car is affected.
7 known faults with sources
Applies if: Toyota USA tech tip for all its models: it applies if the judder began after wheels, pads or discs were removed or changed.
Brake judder from wheel nuts over-tightened or tightened unevenly (Toyota tech tip)Brakes
- Engine / equipment
- Any Toyota: it depends on how the wheels are tightened
- Period mentioned
- 2016 tech tip for all its models
- Symptoms
- Vibration in the steering wheel and the pedal when braking, even gently and at any speed, often shortly after wheels, pads or discs were changed.
- Possible cause described
- Toyota points out in a tech tip that if the wheel nuts are over-tightened or tightened unevenly (a single one is enough), the brake disc is left with runout and brake judder appears. It happens above all when they are run fully home with an impact gun instead of a torque wrench in a star pattern.
- Check for the garage
- Ask the garage to loosen and re-tighten the nuts with a torque wrench, to the manual's torque and in a star pattern, and to measure whether the discs have been left warped; if so, they will need skimming or replacing.
- Cost cited in the source
- No verified estimate; ask the garage for a quote.A rough figure from the original database, not an up-to-date quote.
Sources from the original database
Toyota tech tip T-TT-0424-16 (NHTSA no. 10132884): brake vibration, the importance of lug nut torque
View full entryIgnition coils and carbon on the 1.2 turbo (8NR-FTS)Engine
- Engine / equipment
- 1.2 turbo petrol (8NR-FTS): Auris, C-HR and Corolla
- Period mentioned
- 2015–2022
- Symptoms
- Poor acceleration and strong jerking, misfires and limp mode; at high mileage, loss of power and higher consumption from carbon on injectors, valves and intake.
- Possible cause described
- The coils fitted up to mid-2018 have a suspected manufacturing defect; Toyota usually replaces them as goodwill. Direct injection encourages carbon build-up.
- Check for the garage
- Read misfire codes and check the coil date; ask for a goodwill replacement; clean the intake if there are deposits.
- Cost cited in the source
- No verified estimate; ask the garage for a quote.A rough figure from the original database, not an up-to-date quote.
Sources from the original database
View full entryApplies if: Weak points of this model from inspections, breakdown statistics and recalls; anything specific to one engine is stated in the sheet.
High-pressure pump, fuel tank, battery and campaigns on the C-HRKnown weak points
- Engine / equipment
- Toyota C-HR (2016–2023, 1.2 turbo and hybrids)
- Period mentioned
- 2016–2023
- Symptoms
- A high-pressure pump that wears and leaks (late 2017–spring 2021); a cracked tank on older hybrids; a 12 V battery that drains with little use or strong sun; badly fitted rear wheel bearings; seat covers that can affect the side airbag.
- Possible cause described
- There was a tank recall (almost always as goodwill) and campaigns for the rear bearings and seat covers; the battery and pump are usually covered by warranty or goodwill.
- Check for the garage
- Check the campaigns by VIN; check for fuel leaks; use the car regularly for the battery.
- Cost cited in the source
- No verified estimate; ask the garage for a quote.A rough figure from the original database, not an up-to-date quote.
Sources from the original database
View full entryApplies if: Only those built from 2020 to 2022.
Will not start because of the 12 V battery on the Toyota RAV4 and C-HRElectrical and electronic systems
- Engine / equipment
- Toyota RAV4 from 2017 to 2022 and C-HR from 2020 to 2022, all versions
- Period mentioned
- RAV4: 2017–2022; C-HR: 2020–2022
- Symptoms
- The car will not start or does not go to “Ready”; when you unlock it, the dashboard and lights come on weakly or not at all, and several warnings may appear at once. It happens mostly after a few days parked.
- Possible cause described
- The ADAC, the German automobile club, analyses its members’ roadside assistance call-outs every year. In its 2025 statistics it places the 2017–2022 RAV4 and the 2020–2022 C-HR among the worst in their class and, for all the Toyotas on its list, gives a faulty 12 V starter battery as the cause of the breakdowns.
- Check for the garage
- Measure the 12 V battery voltage and load-test it; check that the system recharges it while driving. If it is weak, replace it and ask Toyota whether there is any action for that model. If the car stays parked for days, a battery maintainer helps.
- Cost cited in the source
- No verified estimate; ask the garage for a quote.A rough figure from the original database, not an up-to-date quote.
Sources from the original database
View full entryToyota C-HR (I) 1.2 T: known faults of the engine according to L'argusEngine
- Engine / equipment
- 1.2 T in the Toyota C-HR (I)
- Period mentioned
- 2016–2023
- Symptoms
- Noise from the engine bay (up to January 2017); Loss of power and engine warning light on; Scraping noise at the exhaust, engine side (up to 09/03/2018)
- Possible cause described
- According to the brand's technical notes reported by L'argus (each date shows up to when the affected cars were built): 1) Noise from the engine bay (up to January 2017): Turbo vacuum regulating valve to be replaced. 2) Loss of power and engine warning light on: Control unit reprogramming (up to 31/03/2017) or ignition coils (up to 24/07/2018). 3) Scraping noise at the exhaust, engine side (up to 09/03/2018): Heat shield mount.
- Check for the garage
- Compare your symptom and your car's build date with this list. If they match, tell the workshop and ask them to check that part first before replacing others. The brand or a warranty extension covers some repairs: ask the dealer with the car's details.
- Cost cited in the source
- No verified estimate; ask the garage for a quote.A rough figure from the original database, not an up-to-date quote.
Sources from the original database
View full entryToyota C-HR (I): known faults of the electronics and interior according to L'argusElectrical and electronic systems
- Engine / equipment
- Toyota C-HR (I), all engines
- Period mentioned
- 2016–2023
- Symptoms
- GPS takes too long to get a signal after switching on; Various multimedia faults; Climate control display fault on cold settings (up to October 2017); No cold air on the 1.8 hybrid (up to January 2018); "Front camera unavailable" message (up to January 2018); Rear parking sensor fault
- Possible cause described
- According to the brand's technical notes reported by L'argus (each date shows up to when the affected cars were built): 1) GPS takes too long to get a signal after switching on: Reposition the internal GPS aerial. 2) Various multimedia faults: Reprogramming. 3) Climate control display fault on cold settings (up to October 2017): Control unit to be replaced. 4) No cold air on the 1.8 hybrid (up to January 2018): Pipes to be replaced. 5) "Front camera unavailable" message (up to January 2018): Camera to be replaced. 6) Rear parking sensor fault: Reprogramming.
- Check for the garage
- Compare your symptom and your car's build date with this list. If they match, tell the workshop and ask them to check that part first before replacing others. The brand or a warranty extension covers some repairs: ask the dealer with the car's details.
- Cost cited in the source
- No verified estimate; ask the garage for a quote.A rough figure from the original database, not an up-to-date quote.
Sources from the original database
View full entryToyota C-HR (I): known faults of the body according to L'argusBodywork
- Engine / equipment
- Toyota C-HR (I), all engines
- Period mentioned
- 2016–2023
- Symptoms
- Wind noise at the windscreen pillar and/or the door mirror (up to July 2017); Water marks inside the rear lights (up to November 2017); Condensation in the headlights (up to 02/09/2022)
- Possible cause described
- According to the brand's technical notes reported by L'argus (each date shows up to when the affected cars were built): 1) Wind noise at the windscreen pillar and/or the door mirror (up to July 2017): Door seal to be replaced. 2) Water marks inside the rear lights (up to November 2017): Lights to be replaced. 3) Condensation in the headlights (up to 02/09/2022): Headlights to be replaced.
- Check for the garage
- Compare your symptom and your car's build date with this list. If they match, tell the workshop and ask them to check that part first before replacing others. The brand or a warranty extension covers some repairs: ask the dealer with the car's details.
- Cost cited in the source
- No verified estimate; ask the garage for a quote.A rough figure from the original database, not an up-to-date quote.