Skip to content
Emergency

Before you buy a used Hyundai ix20.

2010–2019 · Petrol / Diesel · 2 engines

Taken only from Testigo's sourced sheets. Use it to question the seller and on the test drive: it does not confirm that any particular car is affected.

Hyundai ix20, real photo of this generation
Harvey Bold · CC0 1.0 · Wikimedia Commons · Photo source

The essentials.

Typical faults by engine

The period and mileage are those mentioned by each sheet's sources. They are not a maintenance interval and do not predict that any particular car will fail.

1.4 / 1.6

Petrol

1.4 / 1.6 CRDi

Diesel

  • Weak points of the small CRDi diesels (U family) from Hyundai and KiaInjection / turbo
    Period mentioned
    Approx. 2005 onwards
    Mileage mentioned
    What the sheet says: German guides rate these engines as robust if maintained: the faults are the typical wear of a modern diesel. Specific points: a stretched chain on some 1.7s (ix35), cracked heads cited by the TÜV on the i30 I, the 1.1 silencer (Rio III), diesel clutches at 60,000–100,000 km (Cee'd I) and a recall of the 1.7 CRDi vacuum pump (5/10/2010–30/4/2011).

    Applies if: U-family CRDi diesel; the specific points were documented on other models with the same engine.

Which engine has the fewest documented faults?

Documented faults and recalls by engine for the Hyundai ix20
EngineDocumented faultsRecalls
1.4 / 1.6Petrol11 with conditions1
1.4 / 1.6 CRDiDiesel11 with conditions1

According to the data we have, all its engines have the same number of documented faults.

We only count the sourced sheets we have. An engine with fewer is not guaranteed to be more reliable: it may have been studied less or sold in smaller numbers.

Official recalls: ask before you pay

A recall existing does not mean this car is affected or that it is still outstanding: it depends on the chassis number, the market and the production date.

  1. Ask the seller for the chassis number (VIN): it has 17 characters, appears in the car's documents and can usually also be seen at the base of the windscreen.
  2. Ask an official Hyundai dealer, or the brand's official website if it lets you check by chassis number, whether each recall has been done or is still outstanding for that VIN.
  3. Manufacturer recalls are normally carried out free of charge by the official service network. If one is outstanding, ask for it to be done before you close the sale.
Hyundai brake recalls (2004–2024)Brakes

How to check it: Check by VIN whether any of the recalls is outstanding (at the dealer or on the DVSA website) and carry out the inspection or replacement it requires.

View full entry

On the test drive: what to look and listen for

Taken from each sheet's symptoms and checks. You can tick off what you have already looked at: it is saved only in this browser.

0 of 2 checked

Timing system

  • Look out for: Chain rattle on cold start or under load, engine warning light and, in the worst case, the chain jumping with serious engine damage.

    Ask them to check: Listen on a cold start; read the camshaft–crankshaft correlation codes; replace chain, tensioner and guides if it rattles; keep to the oil-change intervals.

Injection / turbo

  • Look out for: At high mileage or with short trips: carbon in injectors and EGR, a clogged particulate filter, dual-mass flywheel and turbo; isolated cases of a stretched chain (1.7) and cracked heads (early 1.6); a clutch that wears early; on some cars, a cracked silencer (1.1) or the brake-servo vacuum pump (1.7 campaign).

    Ask them to check: Drive long trips to regenerate the filter; listen to the chain when cold; test injectors and EGR; check the vacuum-pump campaign by VIN on the 1.7.

Sources

Every fact on this page comes from these Testigo sheets and their original sources. Sources are not checked in real time.

More Hyundai buying guides

View the model pageAll buying guides